Change Car Particulate Filter (DPF) Fiat Scudo

Change Car Particulate Filter (DPF)

Easy 0h30–1h30 ~50–150£
Estimated time 0h30–1h30
Estimated labour cost ~50–150£
Difficulty Easy
Vehicles
Scudo 1995-2007 4
  • 1.9D 8V Diesel (DW8 (WJY))
  • 2.0 16V JTD Diesel (DW10ATED4 (RHW))
  • 2.0 8V JTD Diesel (DW10ATED (RHZ))
  • 2.0 8V JTD Diesel (DW10BTED (RHX))
Scudo 2007-2025 7
  • 1.6 HDi 16V 90 Diesel (DV6UTED4 (9HU))
  • 1.6 MultiJet 8V 90 Diesel (DV6UC (9HM))
  • 2.0 HDi 16V 120 Diesel (DW10UTED4 (RHK))
  • 2.0 HDiF 16V 120 Diesel (DW10UTED4 (RHG))
  • 2.0 HDiF 16V 140 Diesel (DW10BTED4 (RHR))
  • 2.0 MultiJet 16V 130 Diesel (DW10CTED4 (AHZ))
  • 2.0 MultiJet 16V 165 Diesel (DW10CTED4 (RHH))
Check the catalytic converter 0h30
Remove/refit the front catalytic converter 1h30
Renew the front catalytic converter 1h30
Remove/refit the catalytic converter 1h30
Renew the catalytic converter 1h30
Remove/refit the diesel particulate filter 1h00
Renew the diesel particulate filter 1h00
Prepare the catalytic converter heat shield for installation* 0h45
Renew the diesel particulate filter fuel additive reservoir 0h30–0h45
Remove/refit the diesel particulate filter fuel additive reservoir 0h30–0h45
Remove/refit the pre-catalytic converter 1h30–2h30
Renew the pre-catalytic converter 1h30–2h30
Remove/refit the diesel particulate filter/catalytic converter assembly 1h30
Renew the diesel particulate filter/catalytic converter assembly 1h30
Check/top up the diesel particulate filter fuel additive 0h45

What is a Fiat Scudo particulate filter?

Diesel engines and direct-injection petrol engines produce soot particles. The particulate filter (DPF/GPF) traps these harmful particles as exhaust gases pass through its honeycomb structure. It is placed on the exhaust line after the catalytic converter.

How does the Fiat Scudo particulate filter work?

As soot accumulates, the filter periodically burns off (regenerates) the trapped particles. Active regeneration raises exhaust temperatures to 550–600°C, burning soot to ash. This occurs every 300–500 km during normal motorway driving. Vehicles driven only on short urban trips may not regenerate properly, leading to blockage.

When should you change the Fiat Scudo particulate filter?

The DPF is designed to last 150,000–250,000 km but depends on driving patterns. Signs of needed replacement: DPF warning light, engine in limp mode, excessive exhaust smoke, or diagnostic scan showing excessive back-pressure or failed regeneration cycles.

Can the Fiat Scudo particulate filter be cleaned instead of replaced?

Yes, professional DPF cleaning can restore a blocked filter at a fraction of replacement cost. However, if the filter substrate is cracked, melted, or structurally damaged, replacement is the only option. Never use a DPF removal/delete service — it is illegal and will fail the MOT/emissions test.

Is it difficult to change the Fiat Scudo particulate filter?

Difficulty level 2/5: technically straightforward but physically demanding due to the filter's location and weight. Key steps: raise the vehicle, disconnect pressure sensors, remove exhaust clamps/bolts, lower the old DPF, fit the new one with new gaskets, reconnect sensors, clear fault codes, perform a forced regeneration cycle.

View all compatible products →
View your Scudo maintenance plan (keep the Scudo token) →

2 models covered

Model Year Range Engines covered Fuel
Scudo 1995-2007 1995-2007 1.6 8V Petrol (220A2000), 1.9D 8V Diesel (DW8 (WJY)), 2.0 16V CF3 Petrol (EW10J4 (RFN)), 2.0 16V JTD Diesel (DW10ATED4 (RHW)), 2.0 8V JTD Diesel (DW10ATED (RHZ)), 2.0 8V JTD Diesel (DW10BTED (RHX)) Diesel, Petrol
Scudo 2007-2025 2007-2025 1.6 HDi 16V 90 Diesel (DV6UTED4 (9HU)), 1.6 MultiJet 8V 90 Diesel (DV6UC (9HM)), 2.0 HDi 16V 120 Diesel (DW10UTED4 (RHK)), 2.0 HDiF 16V 120 Diesel (DW10UTED4 (RHG)), 2.0 HDiF 16V 140 Diesel (DW10BTED4 (RHR)), 2.0 MultiJet 16V 130 Diesel (DW10CTED4 (AHZ)), 2.0 MultiJet 16V 165 Di… Diesel

Other repair guides

Change Car Accessory Belt Kit

Change Car Accessory Belt Kit

Easy 0h45–1h00
Change Car Air Filter

Change Car Air Filter

Very easy 0h30–0h30
Change Car Battery

Change Car Battery

Very easy 0h30–0h30
Change Car Cabin Filter

Change Car Cabin Filter

Very easy 0h30–0h30
Change Car Clutch

Change Car Clutch

Technical 9h00–19h00
Change Car Front Brake Discs and Pads

Change Car Front Brake Discs and Pads

Easy 1h30–2h00
Change Car Front Brake Pads

Change Car Front Brake Pads

Easy 0h45–1h30
Change Car Fuel Filter

Change Car Fuel Filter

Easy 0h30–0h45
Change Car Handbrake Cable

Change Car Handbrake Cable

Very easy 0h30
Change Car Oil Filter

Change Car Oil Filter

Easy 0h30–0h45
Change Car Rear Silencer

Change Car Rear Silencer

Easy 0h45–1h30
Change Car Shock Absorbers

Change Car Shock Absorbers

Easy 2h00–3h00
Change Car Timing Belt Kit

Change Car Timing Belt Kit

Very technical 4h00–10h00
Change Car Turbo

Change Car Turbo

Very technical 2h30–11h00
Change Car Water Pump

Change Car Water Pump

Easy 3h30–8h00
Change Car Glow Plugs

Change Car Glow Plugs

Intermediate 0h45–7h00
Change Car Spark Plugs

Change Car Spark Plugs

Easy 0h45
View the service schedule for your Scudo →