Change Car Particulate Filter (DPF) BMW 7-Series
Change Car Particulate Filter (DPF)
| Estimated time | 0h30–2h00 |
|---|---|
| Estimated labour cost | ~50–200£ |
| Difficulty | Easy |
| Vehicles |
7-Series 2001-2008 4
7-Series 2008-2015 7
7-Series 2015-2025 5
|
| Check the catalytic converter | 0h30 |
| Check the diesel particulate filter | 0h30 |
| Remove/refit the catalytic converter | 1h30–2h00 |
| Renew the catalytic converter | 1h30–2h00 |
| Remove/refit the diesel particulate filter | 1h30–12h00 |
| Renew the diesel particulate filter | 1h30–12h00 |
| Prepare the catalytic converter heat shield for installation* | 0h45 |
| Remove/refit the left catalytic converter | 1h30 |
| Renew the left catalytic converter | 1h30 |
| Remove/refit the right catalytic converter | 1h00 |
| Renew the right catalytic converter | 1h00 |
| Remove/refit both catalytic converters | 2h00 |
| Renew both catalytic converters | 2h00 |
| Remove/refit the diesel particulate filter/catalytic converter assembly | 1h30–15h00 |
| Renew the diesel particulate filter/catalytic converter assembly | 1h30–15h00 |
| Remove/refit the left diesel particulate filter/catalytic converter assembly | 2h30 |
| Renew the left diesel particulate filter/catalytic converter assembly | 2h30 |
| Remove/refit the right diesel particulate filter/catalytic converter assembly | 2h30 |
| Renew the right diesel particulate filter/catalytic converter assembly | 2h30 |
| Remove/refit both diesel particulate filters/catalytic converter assemblies | 4h00 |
| Renew both diesel particulate filters/catalytic converter assemblies | 4h00 |
| Remove/refit the diesel particulate filter Rear-wheel drive | 3h00 |
| Renew the diesel particulate filter Rear-wheel drive | 3h00 |
| Remove/refit the diesel particulate filter 4WD | 4h00 |
| Renew the diesel particulate filter 4WD | 4h00 |
What is a BMW 7-Series particulate filter?
Diesel engines and direct-injection petrol engines produce soot particles. The particulate filter (DPF/GPF) traps these harmful particles as exhaust gases pass through its honeycomb structure. It is placed on the exhaust line after the catalytic converter.
How does the BMW 7-Series particulate filter work?
As soot accumulates, the filter periodically burns off (regenerates) the trapped particles. Active regeneration raises exhaust temperatures to 550–600°C, burning soot to ash. This occurs every 300–500 km during normal motorway driving. Vehicles driven only on short urban trips may not regenerate properly, leading to blockage.
When should you change the BMW 7-Series particulate filter?
The DPF is designed to last 150,000–250,000 km but depends on driving patterns. Signs of needed replacement: DPF warning light, engine in limp mode, excessive exhaust smoke, or diagnostic scan showing excessive back-pressure or failed regeneration cycles.
Can the BMW 7-Series particulate filter be cleaned instead of replaced?
Yes, professional DPF cleaning can restore a blocked filter at a fraction of replacement cost. However, if the filter substrate is cracked, melted, or structurally damaged, replacement is the only option. Never use a DPF removal/delete service — it is illegal and will fail the MOT/emissions test.
Is it difficult to change the BMW 7-Series particulate filter?
Difficulty level 2/5: technically straightforward but physically demanding due to the filter's location and weight. Key steps: raise the vehicle, disconnect pressure sensors, remove exhaust clamps/bolts, lower the old DPF, fit the new one with new gaskets, reconnect sensors, clear fault codes, perform a forced regeneration cycle.
3 models covered
| Model | Year Range | Engines covered | Fuel |
|---|---|---|---|
| 7-Series 2001-2008 | 2001-2008 | 730d Diesel (M57D30TU), 730d, Ld Diesel (M57D30T2), 730i, Li Petrol (M54B30), 730i, Li, -LPG LPG,Petrol (N52B30A), 735i, Li, -LPG LPG,Petrol (N62B36A), 740d Diesel (M67D39), 740i, Li Petrol (N62B40A), 745d Diesel (M67D44), 745i, Li, -LPG LPG,Petrol (N62B44A), 750i, Li, -LPG LPG,… | Diesel, LPG, Petrol |
| 7-Series 2008-2015 | 2008-2015 | 725d Diesel (N57D30A), 730d Diesel (N57D30A), 730d, -xDrive Diesel (N57D30A), 730d, -xDrive Diesel (N57D30A), 740d, -xDrive Diesel (N57D30B), 740d, -xDrive Diesel (N57D30B), 740i Petrol (N54B30A), 740i Petrol (N55B30A), 750d, -xDrive Diesel (N57D30C), 750i, Li, -xDrive Petrol (N… | Diesel, Petrol |
| 7-Series 2015-2025 | 2015-2025 | 725d Diesel (B47D20B), 725d, Ld Diesel (B47D20B), 730d, Ld, -xDrive Diesel (B57D30A), 730i, Li Petrol (B48B20B), 740d xDrive Diesel (B57D30B), 740e, Le iPerformance Electricity,Petrol (B48B20B+GC1), 740i, Li Petrol (B58B30A), 740i, Li, -xDrive Petrol (B58B30C), 750d, Ld, -xDrive… | Diesel, Electricity, Petrol |
Products related to these vehicles
-
- Online
-
- Make Loading
- Model Loading
- Year Loading
- Sub-Model Loading
- Engine Loading
Loading compatibility information for your vehicle
-
- Online
-
- Make Loading
- Model Loading
- Year Loading
- Sub-Model Loading
- Engine Loading
Loading compatibility information for your vehicle
-
- Online
-
- Make Loading
- Model Loading
- Year Loading
- Sub-Model Loading
- Engine Loading
Loading compatibility information for your vehicle
