Change Car Particulate Filter (DPF) Toyota Yaris

Change Car Particulate Filter (DPF)

Easy 0h30–1h00 ~50–100£
Estimated time 0h30–1h00
Estimated labour cost ~50–100£
Difficulty Easy
Vehicles
Yaris 1999-2006 1
  • 1.4 D4-D Diesel (1ND-TV)
Yaris 2005-2013 1
  • 1.4 D-4D Diesel (1ND-TV)
Yaris 2011-2020 1
  • 1.4 D-4D Diesel (1ND-TV)
Remove/refit the catalytic converter 1h00–2h00
Renew the catalytic converter 1h00–2h00
Prepare the catalytic converter heat shield for installation* 0h45
Check the catalytic converter 0h30
Renew the catalytic converter gasket 1h30
Remove/refit the diesel particulate filter 5h00
Renew the diesel particulate filter 5h00
Remove/refit the diesel particulate filter/catalytic converter assembly 5h00–6h00
Renew the diesel particulate filter/catalytic converter assembly 5h00–6h00

What is a Toyota Yaris particulate filter?

Diesel engines and direct-injection petrol engines produce soot particles. The particulate filter (DPF/GPF) traps these harmful particles as exhaust gases pass through its honeycomb structure. It is placed on the exhaust line after the catalytic converter.

How does the Toyota Yaris particulate filter work?

As soot accumulates, the filter periodically burns off (regenerates) the trapped particles. Active regeneration raises exhaust temperatures to 550–600°C, burning soot to ash. This occurs every 300–500 km during normal motorway driving. Vehicles driven only on short urban trips may not regenerate properly, leading to blockage.

When should you change the Toyota Yaris particulate filter?

The DPF is designed to last 150,000–250,000 km but depends on driving patterns. Signs of needed replacement: DPF warning light, engine in limp mode, excessive exhaust smoke, or diagnostic scan showing excessive back-pressure or failed regeneration cycles.

Can the Toyota Yaris particulate filter be cleaned instead of replaced?

Yes, professional DPF cleaning can restore a blocked filter at a fraction of replacement cost. However, if the filter substrate is cracked, melted, or structurally damaged, replacement is the only option. Never use a DPF removal/delete service — it is illegal and will fail the MOT/emissions test.

Is it difficult to change the Toyota Yaris particulate filter?

Difficulty level 2/5: technically straightforward but physically demanding due to the filter's location and weight. Key steps: raise the vehicle, disconnect pressure sensors, remove exhaust clamps/bolts, lower the old DPF, fit the new one with new gaskets, reconnect sensors, clear fault codes, perform a forced regeneration cycle.

View all compatible products →
View your Yaris maintenance plan (keep the Yaris token) →

4 models covered

Model Year Range Engines covered Fuel
Yaris 1999-2006 1999-2006 1.0 VVT-i Petrol (1SZ-FE), 1.0 VVT-i Petrol (1SZ-FE), 1.3 VVT-i Petrol (2NZ-FE), 1.3 VVT-i Petrol (2SZ-FE), 1.4 D4-D Diesel (1ND-TV), 1.5 VVT-i TS Petrol (1NZ-FE) Diesel, Petrol
Yaris 2005-2013 2005-2013 1.0 12V VVT-i, -LPG LPG,Petrol (1KR-FE), 1.3 16V VVT-i Petrol (2NZ-FE), 1.3 16V VVT-i Petrol (2SZ-FE), 1.33 16V VVT-i Petrol (1NR-FE), 1.4 D-4D Diesel (1ND-TV), 1.5 16V VVT-i Petrol (1NZ-FE), 1.8 16V VVT-i TS Petrol (2ZR-FE) Diesel, LPG, Petrol
Yaris 2011-2020 2011-2020 1.0 12V VVT-i Petrol (1KR-FE), 1.33 Petrol (1NR-FE), 1.4 D-4D Diesel (1ND-TV), 1.5 Hybrid Electricity,Petrol (1NZ-FXE), 1.5 Petrol (2NR-FKE) Diesel, Electricity, Petrol
Yaris 2020-2025 2020-2025 1.0 Petrol (1KR-FE), 1.5 HEV Electricity,Petrol (M15A-FXE), 1.5 Petrol (M15A-FKS) Electricity, Petrol

Other repair guides

Change Car Battery

Change Car Battery

Very easy 0h30–0h45
Change Car Front Brake Discs and Pads

Change Car Front Brake Discs and Pads

Easy 1h30
Change Car Front Brake Pads

Change Car Front Brake Pads

Easy 1h30
Change Car Fuel Filter

Change Car Fuel Filter

Easy 0h45–2h30
Change Car Handbrake Cable

Change Car Handbrake Cable

Very easy 0h30
Change Car Oil Filter

Change Car Oil Filter

Easy 0h30–1h30
Change Car Rear Silencer

Change Car Rear Silencer

Easy 0h45–1h30
Change Car Water Pump

Change Car Water Pump

Easy 1h30–3h00
Change Car Accessory Belt Kit

Change Car Accessory Belt Kit

Easy 0h30–1h30
Change Car Air Filter

Change Car Air Filter

Very easy 0h30
Change Car Cabin Filter

Change Car Cabin Filter

Very easy 0h30–0h45
Change Car Clutch

Change Car Clutch

Technical 8h00–13h00
Change Car Glow Plugs

Change Car Glow Plugs

Intermediate 0h30–1h30
Change Car Shock Absorbers

Change Car Shock Absorbers

Easy 3h00–5h00
Change Car Spark Plugs

Change Car Spark Plugs

Easy 0h30–0h45
Change Car Turbo

Change Car Turbo

Very technical 3h30–5h00
View the service schedule for your Yaris →