Change Car Particulate Filter (DPF) Ford Transit Connect

Change Car Particulate Filter (DPF)

Easy 0h30–2h00 ~50–200£
Estimated time 0h30–2h00
Estimated labour cost ~50–200£
Difficulty Easy
Vehicles
Transit Connect 2002-2013 14
  • 1.8 TDCi (Duratorq) Diesel (HCPA)
  • 1.8 TDCi (Duratorq) Diesel (HCPB)
  • 1.8 TDCi (Duratorq) Diesel (HCPC)
  • 1.8 TDCi (Duratorq) Diesel (P7PA)
  • 1.8 TDCi (Duratorq) Diesel (P7PB)
  • 1.8 TDCi (Duratorq) Diesel (P9PA)
  • 1.8 TDCi (Duratorq) Diesel (P9PC)
  • 1.8 TDCi (Duratorq) Diesel (R2PA)
  • 1.8 TDCi (Duratorq) Diesel (R3PA)
  • 1.8 TDCi (Duratorq) Diesel (RWPA)
  • 1.8 TDCi (Duratorq) Diesel (RWPC)
  • 1.8 TDCi (Duratorq) Diesel (RWPD)
  • 1.8 TDdi (Duratorq) Diesel (BHPA)
  • 1.8 TDdi (Duratorq) Diesel (BHPB)
Transit Connect 2013-2023 15
  • 1.5 TDCi (Duratorq) Diesel (XUGA)
  • 1.5 TDCi (Duratorq) Diesel (XVGA)
  • 1.5 TDCi (Duratorq) Diesel (XVGB)
  • 1.5 TDCi (Duratorq) Diesel (XVGC)
  • 1.5 TDCi (Duratorq) Diesel (XWGA)
  • 1.5 TDCi (Duratorq) Diesel (XWGB)
  • 1.5 TDCi (Duratorq) Diesel (XWGC)
  • 1.5 TDCi (Duratorq) Diesel (XXGA)
  • 1.5 TDCi (EcoBlue) Diesel (BEGA)
  • 1.5 TDCi (EcoBlue) Diesel (Z2GA)
  • 1.5 TDCi (EcoBlue) Diesel (ZTGA)
  • 1.6 TDCi (Duratorq) Diesel (T1GA)
  • 1.6 TDCi (Duratorq) Diesel (TZGA)
  • 1.6 TDCi (Duratorq) Diesel (TZGB)
  • 1.6 TDCi (Duratorq) Diesel (UBGA)
Remove/refit the fuel vaporisation assembly 2h00
Renew the fuel vaporisation assembly 2h00
Check the catalytic converter 0h30
Remove/refit the catalytic converter EURO 5 2h00
Remove/refit the catalytic converter 1h30–3h00
Renew the catalytic converter EURO 5 0h45
Renew the catalytic converter 1h30–3h00
Remove/refit the diesel particulate filter 1h00–2h30
Remove/refit the diesel particulate filter fuel additive injector 0h45–2h00
Renew the diesel particulate filter 1h00–2h30
Renew the diesel particulate filter fuel additive injector 0h45–2h00
Prepare the catalytic converter heat shield for installation* 0h45
Remove/refit the rear catalytic converter 0h45–1h30
Renew the rear catalytic converter 0h45–1h30
Renew the diesel particulate filter fuel additive reservoir 2h00
Remove/refit the diesel particulate filter fuel additive reservoir 2h00
Remove/refit the diesel particulate filter/catalytic converter assembly 2h30
Renew the diesel particulate filter/catalytic converter assembly 2h30
Remove/refit the AdBlue tank control unit 0h45
Remove/refit the AdBlue tank 2h00
Renew the AdBlue tank control unit 0h45
Renew the AdBlue tank 2h00
Remove/refit the catalytic converter Air-cooled intercooler 3h00
Remove/refit the catalytic converter Water-cooled intercooler 3h00
Renew the catalytic converter Water-cooled intercooler 3h00
Renew the catalytic converter Air-cooled intercooler 3h00
Remove/refit the diesel particulate filter Air-cooled intercooler 3h00
Remove/refit the diesel particulate filter Water-cooled intercooler 3h00
Renew the diesel particulate filter Air-cooled intercooler 3h00
Renew the diesel particulate filter Water-cooled intercooler 3h00

What is a Ford Transit Connect particulate filter?

Diesel engines and direct-injection petrol engines produce soot particles. The particulate filter (DPF/GPF) traps these harmful particles as exhaust gases pass through its honeycomb structure. It is placed on the exhaust line after the catalytic converter.

How does the Ford Transit Connect particulate filter work?

As soot accumulates, the filter periodically burns off (regenerates) the trapped particles. Active regeneration raises exhaust temperatures to 550–600°C, burning soot to ash. This occurs every 300–500 km during normal motorway driving. Vehicles driven only on short urban trips may not regenerate properly, leading to blockage.

When should you change the Ford Transit Connect particulate filter?

The DPF is designed to last 150,000–250,000 km but depends on driving patterns. Signs of needed replacement: DPF warning light, engine in limp mode, excessive exhaust smoke, or diagnostic scan showing excessive back-pressure or failed regeneration cycles.

Can the Ford Transit Connect particulate filter be cleaned instead of replaced?

Yes, professional DPF cleaning can restore a blocked filter at a fraction of replacement cost. However, if the filter substrate is cracked, melted, or structurally damaged, replacement is the only option. Never use a DPF removal/delete service — it is illegal and will fail the MOT/emissions test.

Is it difficult to change the Ford Transit Connect particulate filter?

Difficulty level 2/5: technically straightforward but physically demanding due to the filter's location and weight. Key steps: raise the vehicle, disconnect pressure sensors, remove exhaust clamps/bolts, lower the old DPF, fit the new one with new gaskets, reconnect sensors, clear fault codes, perform a forced regeneration cycle.

View all compatible products →
View your Transit Connect maintenance plan (keep the Transit Connect token) →

2 models covered

Model Year Range Engines covered Fuel
Transit Connect 2002-2013 2002-2013 1.8 (Duratec) Petrol (EYPA), 1.8 TDCi (Duratorq) Diesel (HCPA), 1.8 TDCi (Duratorq) Diesel (HCPB), 1.8 TDCi (Duratorq) Diesel (HCPC), 1.8 TDCi (Duratorq) Diesel (P7PA), 1.8 TDCi (Duratorq) Diesel (P7PB), 1.8 TDCi (Duratorq) Diesel (P9PA), 1.8 TDCi (Duratorq) Diesel (P9PC), 1.8 T… Diesel, Petrol
Transit Connect 2013-2023 2013-2023 1.0 (EcoBoost) Petrol (B3GA), 1.0 (EcoBoost) Petrol (M2GA), 1.0 (EcoBoost) Petrol (M2GB), 1.5 TDCi (Duratorq) Diesel (XUGA), 1.5 TDCi (Duratorq) Diesel (XVGA), 1.5 TDCi (Duratorq) Diesel (XVGB), 1.5 TDCi (Duratorq) Diesel (XVGC), 1.5 TDCi (Duratorq) Diesel (XWGA), 1.5 TDCi (Dura… Diesel, Petrol

Other repair guides

Change Car Accessory Belt Kit

Change Car Accessory Belt Kit

Easy 0h45–1h30
Change Car Air Filter

Change Car Air Filter

Very easy 0h30–0h45
Change Car Battery

Change Car Battery

Very easy 0h30–0h45
Change Car Cabin Filter

Change Car Cabin Filter

Very easy 0h30–0h45
Change Car Clutch

Change Car Clutch

Technical 8h00–9h00
Change Car Front Brake Discs and Pads

Change Car Front Brake Discs and Pads

Easy 1h30
Change Car Front Brake Pads

Change Car Front Brake Pads

Easy 1h30
Change Car Fuel Filter

Change Car Fuel Filter

Easy 0h45–1h30
Change Car Glow Plugs

Change Car Glow Plugs

Intermediate 0h45–3h30
Change Car Handbrake Cable

Change Car Handbrake Cable

Very easy 0h30
Change Car Oil Filter

Change Car Oil Filter

Easy 0h30–1h30
Change Car Rear Silencer

Change Car Rear Silencer

Easy 0h45–1h30
Change Car Shock Absorbers

Change Car Shock Absorbers

Easy 3h00–6h00
Change Car Spark Plugs

Change Car Spark Plugs

Easy 1h00–1h30
Change Car Timing Belt Kit

Change Car Timing Belt Kit

Very technical 5h00–14h00
Change Car Turbo

Change Car Turbo

Very technical 5h00–7h00
Change Car Water Pump

Change Car Water Pump

Easy 2h00–5h00
View the service schedule for your Transit Connect →