Change Car Particulate Filter (DPF) Kia Cee'd

Change Car Particulate Filter (DPF)

Easy 0h30–2h30 ~50–250£
Estimated time 0h30–2h30
Estimated labour cost ~50–250£
Difficulty Easy
Vehicles
Cee'd 2007-2012 6
  • 1.6 CRDi 16V Diesel (D4FB)
  • 1.6 CRDi 16V Diesel (D4FB-5)
  • 1.6 CRDi 16V Diesel (D4FB-5)
  • 1.6 CRDi 16V Diesel (D4FB-L)
  • 1.6 CRDi Diesel (D4FB)
  • 2.0 CRDi 16V Diesel (D4EA-F)
Cee'd 2013-2018 4
  • 1.4 CRDi Diesel (D4FC)
  • 1.6 CRDi Diesel (D4FB)
  • 1.6 CRDi Diesel (D4FB)
  • 1.6 CRDi Diesel (D4FB)
Check the catalytic converter 0h30
Remove/refit the catalytic converter 0h45–2h30
Renew the catalytic converter 0h45–2h30
Remove/refit the diesel particulate filter 0h45
Renew the diesel particulate filter 0h45
Remove/refit the diesel particulate filter/catalytic converter assembly 0h45–2h30
Renew the diesel particulate filter/catalytic converter assembly 0h45–2h30
Prepare the catalytic converter heat shield for installation* 0h45

What is a Kia Cee'd particulate filter?

Diesel engines and direct-injection petrol engines produce soot particles. The particulate filter (DPF/GPF) traps these harmful particles as exhaust gases pass through its honeycomb structure. It is placed on the exhaust line after the catalytic converter.

How does the Kia Cee'd particulate filter work?

As soot accumulates, the filter periodically burns off (regenerates) the trapped particles. Active regeneration raises exhaust temperatures to 550–600°C, burning soot to ash. This occurs every 300–500 km during normal motorway driving. Vehicles driven only on short urban trips may not regenerate properly, leading to blockage.

When should you change the Kia Cee'd particulate filter?

The DPF is designed to last 150,000–250,000 km but depends on driving patterns. Signs of needed replacement: DPF warning light, engine in limp mode, excessive exhaust smoke, or diagnostic scan showing excessive back-pressure or failed regeneration cycles.

Can the Kia Cee'd particulate filter be cleaned instead of replaced?

Yes, professional DPF cleaning can restore a blocked filter at a fraction of replacement cost. However, if the filter substrate is cracked, melted, or structurally damaged, replacement is the only option. Never use a DPF removal/delete service — it is illegal and will fail the MOT/emissions test.

Is it difficult to change the Kia Cee'd particulate filter?

Difficulty level 2/5: technically straightforward but physically demanding due to the filter's location and weight. Key steps: raise the vehicle, disconnect pressure sensors, remove exhaust clamps/bolts, lower the old DPF, fit the new one with new gaskets, reconnect sensors, clear fault codes, perform a forced regeneration cycle.

View all compatible products →
View your Cee'd maintenance plan (keep the Cee'd token) →

2 models covered

Model Year Range Engines covered Fuel
Cee'd 2007-2012 2007-2012 1.4 16V Petrol (G4FA), 1.4 16V Petrol (G4FA-5), 1.4 16V Petrol (G4FA-5), 1.4 16V Petrol (G4FA-L), 1.6 16V CVVT Petrol (G4FC-5L), 1.6 16V Petrol (G4FC), 1.6 16V Petrol (G4FC), 1.6 16V Petrol (G4FC-L), 1.6 CRDi 16V Diesel (D4FB), 1.6 CRDi 16V Diesel (D4FB-5), 1.6 CRDi 16V Diesel (… Diesel, Petrol
Cee'd 2013-2018 2013-2018 1.0 T-GDi Petrol (G3LC), 1.4 CRDi Diesel (D4FC), 1.4 CVVT Petrol (G4FA), 1.4 MPi Petrol (G4LC), 1.6 CRDi Diesel (D4FB), 1.6 CRDi Diesel (D4FB), 1.6 CRDi Diesel (D4FB), 1.6 GDi Petrol (G4FD), 1.6 T-GDi Petrol (G4FJ) Diesel, Petrol

Other repair guides

Change Car Accessory Belt Kit

Change Car Accessory Belt Kit

Easy 0h30–0h45
Change Car Air Filter

Change Car Air Filter

Very easy 0h30
Change Car Battery

Change Car Battery

Very easy 0h30
Change Car Cabin Filter

Change Car Cabin Filter

Very easy 0h30–1h00
Change Car Front Brake Discs and Pads

Change Car Front Brake Discs and Pads

Easy 1h30
Change Car Front Brake Pads

Change Car Front Brake Pads

Easy 0h45
Change Car Fuel Filter

Change Car Fuel Filter

Easy 0h45–1h00
Change Car Handbrake Cable

Change Car Handbrake Cable

Very easy 0h30
Change Car Oil Filter

Change Car Oil Filter

Easy 0h45
Change Car Rear Silencer

Change Car Rear Silencer

Easy 0h30–1h30
Change Car Shock Absorbers

Change Car Shock Absorbers

Easy 2h00–2h30
Change Car Water Pump

Change Car Water Pump

Easy 1h30–3h00
Change Car Clutch

Change Car Clutch

Technical 6h00–8h00
Change Car Glow Plugs

Change Car Glow Plugs

Intermediate 1h30
Change Car Spark Plugs

Change Car Spark Plugs

Easy 0h30–1h00
Change Car Timing Belt Kit

Change Car Timing Belt Kit

Very technical 4h00–8h00
Change Car Turbo

Change Car Turbo

Very technical 1h30–7h00
View the service schedule for your Cee'd →