Change Car Particulate Filter (DPF) Ford Transit Custom Nugget

Change Car Particulate Filter (DPF)

Easy 0h45–16h00 ~75–1600£
Estimated time 0h45–16h00
Estimated labour cost ~75–1600£
Difficulty Easy
Vehicles
Transit Custom Nugget 2013-2023 32
  • 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BCFC)
  • 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BCFD)
  • 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BJFC)
  • 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BKFC)
  • 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BKFD)
  • 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BLFC)
  • 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BLFD)
  • 2.0 TDCi (EcoBlue) 48V (MHEV),Diesel (P0FB)
  • 2.0 TDCi (EcoBlue) Diesel (BCFA)
  • 2.0 TDCi (EcoBlue) Diesel (BCFB)
  • 2.0 TDCi (EcoBlue) Diesel (BCFF)
  • 2.0 TDCi (EcoBlue) Diesel (BJFA)
  • 2.0 TDCi (EcoBlue) Diesel (BJFB)
  • 2.0 TDCi (EcoBlue) Diesel (BKFA)
  • 2.0 TDCi (EcoBlue) Diesel (BKFB)
  • 2.0 TDCi (EcoBlue) Diesel (BLFA)
  • 2.0 TDCi (EcoBlue) Diesel (BLFB)
  • 2.0 TDCi (EcoBlue) Diesel (P0FA)
  • 2.0 TDCi (EcoBlue) Diesel (YLF6)
  • 2.0 TDCi (EcoBlue) Diesel (YLFA)
  • 2.0 TDCi (EcoBlue) Diesel (YLFS)
  • 2.0 TDCi (EcoBlue) Diesel (YMF6)
  • 2.0 TDCi (EcoBlue) Diesel (YMFA)
  • 2.0 TDCi (EcoBlue) Diesel (YMFS)
  • 2.0 TDCi (EcoBlue) Diesel (YNF6)
  • 2.0 TDCi (EcoBlue) Diesel (YNFA)
  • 2.0 TDCi (EcoBlue) Diesel (YNFS)
  • 2.0 TDCi (EcoBlue) Diesel (YNR6)
  • 2.2 TDCi (Duratorq) Diesel (CVFF)
  • 2.2 TDCi (Duratorq) Diesel (CYFF)
  • 2.2 TDCi (Duratorq) Diesel (DRFF)
  • 2.2 TDCi (Duratorq) Diesel (DRFG)
Transit Custom Nugget 2023-2025 7
  • 2.0 EcoBlue Diesel (BCFA)
  • 2.0 EcoBlue Diesel (BFJA)
  • 2.0 EcoBlue Diesel (BJAA)
  • 2.0 EcoBlue Diesel (BJFA)
  • 2.0 EcoBlue Diesel (BKAA)
  • 2.0 EcoBlue Diesel (BKFA)
  • 2.0 EcoBlue Diesel (BKFB)
Remove/refit the catalytic converter 3h30
Renew the catalytic converter 3h30
Remove/refit the diesel particulate filter 3h30
Renew the diesel particulate filter 3h30
Prepare the catalytic converter heat shield for installation* 0h45
Carry out the diesel particulate filter regeneration procedure 1h30
Check/top up the diesel particulate filter fuel additive 0h30
Remove/refit the catalytic converter VMT6, Front-wheel drive 3h30
Remove/refit the catalytic converter 6F55, Front-wheel drive 3h30
Renew the catalytic converter 6F55, Front-wheel drive 3h30
Renew the catalytic converter VMT6, Front-wheel drive 3h30
Remove/refit the diesel particulate filter 6F55, Front-wheel drive 3h30
Remove/refit the diesel particulate filter VMT6, Front-wheel drive 3h30
Renew the diesel particulate filter VMT6, Front-wheel drive 3h30
Renew the diesel particulate filter 6F55, Front-wheel drive 3h30
Remove/refit the AdBlue tank 1h30–2h00
Drain/refill the AdBlue tank 0h30–0h45
Renew the AdBlue tank 1h30–2h00
Remove/refit the AdBlue system control unit 0h45
Renew the AdBlue system control unit 0h45
Remove/refit the AdBlue injector Manual transmission 2h30
Remove/refit the AdBlue injector Automatic transmission 2h00
Renew the AdBlue injector Manual transmission 2h30
Renew the AdBlue injector Automatic transmission 2h00
Remove/refit the diesel particulate filter fuel additive injector 2h00
Renew the diesel particulate filter fuel additive injector 2h00
Remove/refit the AdBlue tank control unit 1h00
Renew the AdBlue tank control unit 1h00
Remove/refit the rear catalytic converter 1h30
Renew the rear catalytic converter 1h30
Renew the diesel particulate filter fuel additive reservoir 1h30
Remove/refit the diesel particulate filter fuel additive reservoir 1h30
Renew the catalytic converter gasket 3h30
Remove/refit the fuel vaporisation assembly 3h00
Renew the fuel vaporisation assembly 3h00
Remove/refit the fuel vaporisation glow plug 1h00
Renew the fuel vaporisation glow plug 1h00
Remove/refit the fuel vaporisation fuel pump 0h45
Renew the fuel vaporisation fuel pump 0h45
Remove/refit the diesel particulate filter/catalytic converter assembly 3h30
Renew the diesel particulate filter/catalytic converter assembly 3h30
Remove/refit the diesel particulate filter Automatic transmission 16h00
Remove/refit the diesel particulate filter Manual transmission 20h00
Renew the diesel particulate filter Manual transmission 20h00
Renew the diesel particulate filter Automatic transmission 16h00
Remove/refit the AdBlue injector 1h30
Renew the AdBlue injector 1h30

What is a Ford Transit Custom Nugget particulate filter?

Diesel engines and direct-injection petrol engines produce soot particles. The particulate filter (DPF/GPF) traps these harmful particles as exhaust gases pass through its honeycomb structure. It is placed on the exhaust line after the catalytic converter.

How does the Ford Transit Custom Nugget particulate filter work?

As soot accumulates, the filter periodically burns off (regenerates) the trapped particles. Active regeneration raises exhaust temperatures to 550–600°C, burning soot to ash. This occurs every 300–500 km during normal motorway driving. Vehicles driven only on short urban trips may not regenerate properly, leading to blockage.

When should you change the Ford Transit Custom Nugget particulate filter?

The DPF is designed to last 150,000–250,000 km but depends on driving patterns. Signs of needed replacement: DPF warning light, engine in limp mode, excessive exhaust smoke, or diagnostic scan showing excessive back-pressure or failed regeneration cycles.

Can the Ford Transit Custom Nugget particulate filter be cleaned instead of replaced?

Yes, professional DPF cleaning can restore a blocked filter at a fraction of replacement cost. However, if the filter substrate is cracked, melted, or structurally damaged, replacement is the only option. Never use a DPF removal/delete service — it is illegal and will fail the MOT/emissions test.

Is it difficult to change the Ford Transit Custom Nugget particulate filter?

Difficulty level 2/5: technically straightforward but physically demanding due to the filter's location and weight. Key steps: raise the vehicle, disconnect pressure sensors, remove exhaust clamps/bolts, lower the old DPF, fit the new one with new gaskets, reconnect sensors, clear fault codes, perform a forced regeneration cycle.

View all compatible products →
View your Transit Custom Nugget maintenance plan (keep the Transit Custom Nugget token) →

2 models covered

Model Year Range Engines covered Fuel
Transit Custom Nugget 2013-2023 2013-2023 1.0 (EcoBoost) + Range Extender PHEV Electricity,Petrol (M1FA), 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BCFC), 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BCFD), 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BJFC), 2.0 mHEV TDCi (EcoBlue) 48V (MHEV),Diesel (BKFC), 2.0 mHEV TDCi (… 48V (MHEV), Diesel, Electricity, Petrol
Transit Custom Nugget 2023-2025 2023-2025 2.0 EcoBlue Diesel (BCFA), 2.0 EcoBlue Diesel (BFJA), 2.0 EcoBlue Diesel (BJAA), 2.0 EcoBlue Diesel (BJFA), 2.0 EcoBlue Diesel (BKAA), 2.0 EcoBlue Diesel (BKFA), 2.0 EcoBlue Diesel (BKFB) Diesel

Other repair guides

Change Car Accessory Belt Kit

Change Car Accessory Belt Kit

Easy 1h30–6h00
Change Car Air Filter

Change Car Air Filter

Very easy 0h30
Change Car Battery

Change Car Battery

Very easy 0h30–1h00
Change Car Cabin Filter

Change Car Cabin Filter

Very easy 0h30
Change Car Clutch

Change Car Clutch

Technical 7h00–24h00
Change Car Front Brake Discs and Pads

Change Car Front Brake Discs and Pads

Easy 1h30–3h30
Change Car Front Brake Pads

Change Car Front Brake Pads

Easy 1h30
Change Car Fuel Filter

Change Car Fuel Filter

Easy 0h45
Change Car Glow Plugs

Change Car Glow Plugs

Intermediate 2h30–3h30
Change Car Handbrake Cable

Change Car Handbrake Cable

Very easy 0h30
Change Car Oil Filter

Change Car Oil Filter

Easy 0h45
Change Car Rear Silencer

Change Car Rear Silencer

Easy 1h00–1h30
Change Car Shock Absorbers

Change Car Shock Absorbers

Easy 3h00–4h00
Change Car Spark Plugs

Change Car Spark Plugs

Easy 1h30
Change Car Timing Belt Kit

Change Car Timing Belt Kit

Very technical 9h00–11h00
Change Car Turbo

Change Car Turbo

Very technical 4h00–27h00
Change Car Water Pump

Change Car Water Pump

Easy 1h00–6h00
View the service schedule for your Transit Custom Nugget →